762273
6
Verklein
Vergroot
Pagina terug
1/120
Pagina verder
6
EN
Make sure that you have masked the areas that
should not be sprayed, using a good quality
masking tape. The paint or fluid to be sprayed
should be thoroughly mixed and free from lumps
or other particles. Many substances can be
sprayed with your spray gun, but always check
the manufacturers recommendations before
purchasing your paint.
Thinning
Always remember to disconnect from the
mains supply before filling the paint
container with sprayable material.
Most paints are supplied ready for brush
application and will need to be thinned before
they are suitable to be sprayed. Follow the
manufacturers advice on thinning the paint when
used with a spray gun. The viscosity cup will help
you to determine the correct viscosity of paint to be
used. To determine the correct viscosity, fill the cup
to the brim with the paint. Measure the amount of
time it takes for the cup to empty back into the can.
The table below shows recommended times for
different types of material.
Plastic & latex paint 24 - 28 seconds
Water based paint 20 - 25 seconds
Primers 24 - 28 seconds
Varnishes 20 - 25 seconds
Oil based paints 18 - 22 seconds
Enamel paints 18 - 22 seconds
Aluminium paints 22 - 25 seconds
Car undersealing 25 - 35 seconds
Wood sealers 28 - 35 seconds
Wood preservatives No thinning required
Wood stains No thinning required
If the paint takes longer than the recommended
time to empty, then further thinning is required. Mix
in a small quantity of the appropriate thinner and
use the viscosity test until the correct thickness
is achieved. Some sprayable materials contain
particles and lumps. These materials should be
strained before filling the paint container.
Spraying
Fig. C
Fill the paint container with the correctly thinned
and strained paint. Connect the spray gun to the
mains supply. Aim the spray gun at a piece of
scrap material and operate the trigger switch until
paint is spraying. Adjust the output control (2)
until the required volume of paint is spraying. Turn
the output control in a clockwise direction (B) to
reduce the flow and anti-clockwise (A) to increase
the flow. Adjustment of the output control will
affect the spray pattern. A poor spray pattern will
concentrate the paint in the centre of the spray and
give a blotchy finish. A good spray pattern will give
even distribution of paint throughout the pattern.
Spraying techniques
Fig. D
To obtain the best results, keep your spray gun
level and parallel to the surface at all times. Keep
the nozzle 25 - 30 cm from the surface and spray
evenly from side to side or up and down. Do not
spray at an angle as this will lead to paint runs on
the surface. Use smooth and even strokes. When
spraying large areas, use a criss-cross pattern as
shown.
Fig. E
Never start or stop the spray gun while it is aimed
at the surface to be sprayed. Evenly control the
speed of movement of the spray gun. A fast
speed of movement over the surface will give
a thin coat and a slow speed will give a heavy
coat. Apply one coat at a time. If a further coat
is required, make sure you observe the manu-
facturers drying time recommendations before
applying a second coat. When spraying small
areas, keep the output control on a low setting.
This will avoid using too much paint and prevent
overspray. Where possible, avoid stopping and
starting when spraying an object. This can lead to
too much, or not enough paint being applied. Do
not tip the spray gun to more than 45°.
Fitting and using the flexible nozzle
Fig. F
The flexible nozzle extension should be used to
spray flat or horizontal surfaces. It should also
be used in areas with limited access. To fit the
flexible nozzle, unscrew the basket nozzle and
attach the flexible nozzle in it‘s place. Replace
the basket nozzle on the end of the flexible nozzle
and tighten.
6

Hulp nodig? Stel uw vraag in het forum

Spelregels

Misbruik melden

Gebruikershandleiding.com neemt misbruik van zijn services uitermate serieus. U kunt hieronder aangeven waarom deze vraag ongepast is. Wij controleren de vraag en zonodig wordt deze verwijderd.

Product:

Bijvoorbeeld antisemitische inhoud, racistische inhoud, of materiaal dat gewelddadige fysieke handelingen tot gevolg kan hebben.

Bijvoorbeeld een creditcardnummer, een persoonlijk identificatienummer, of een geheim adres. E-mailadressen en volledige namen worden niet als privégegevens beschouwd.

Spelregels forum

Om tot zinvolle vragen te komen hanteren wij de volgende spelregels:

Belangrijk! Als er een antwoord wordt gegeven op uw vraag, dan is het voor de gever van het antwoord nuttig om te weten als u er wel (of niet) mee geholpen bent! Wij vragen u dus ook te reageren op een antwoord.

Belangrijk! Antwoorden worden ook per e-mail naar abonnees gestuurd. Laat uw emailadres achter op deze site, zodat u op de hoogte blijft. U krijgt dan ook andere vragen en antwoorden te zien.

Abonneren

Abonneer u voor het ontvangen van emails voor uw Ferm SGM1012 bij:


U ontvangt een email met instructies om u voor één of beide opties in te schrijven.


Ontvang uw handleiding per email

Vul uw emailadres in en ontvang de handleiding van Ferm SGM1012 in de taal/talen: Alle talen als bijlage per email.

De handleiding is 10,12 mb groot.

 

U ontvangt de handleiding per email binnen enkele minuten. Als u geen email heeft ontvangen, dan heeft u waarschijnlijk een verkeerd emailadres ingevuld of is uw mailbox te vol. Daarnaast kan het zijn dat uw internetprovider een maximum heeft aan de grootte per email. Omdat hier een handleiding wordt meegestuurd, kan het voorkomen dat de email groter is dan toegestaan bij uw provider.

Uw handleiding is per email verstuurd. Controleer uw email

Als u niet binnen een kwartier uw email met handleiding ontvangen heeft, kan het zijn dat u een verkeerd emailadres heeft ingevuld of dat uw emailprovider een maximum grootte per email heeft ingesteld die kleiner is dan de grootte van de handleiding.

Er is een email naar u verstuurd om uw inschrijving definitief te maken.

Controleer uw email en volg de aanwijzingen op om uw inschrijving definitief te maken

U heeft geen emailadres opgegeven

Als u de handleiding per email wilt ontvangen, vul dan een geldig emailadres in.

Uw vraag is op deze pagina toegevoegd

Wilt u een email ontvangen bij een antwoord en/of nieuwe vragen? Vul dan hier uw emailadres in.



Info